Krudico Logo
   
Water Treatment Professionals
Krudico Main Window Top


The Most Econimical and the Ultimate System to Continuously Oxidize Iron and Manganese in Your Water or to Expel Hydrogen Sulfide Gas
Click Here
to Order
 
AIR CHARGER 1 TANK SPECIFICATIONS
MODEL TANK SIZE
(size inches)		 SERVICE FLOW
(gpm)		 IRON LIMITS*
(ppm)		 MANGANESE
LIMITS*
(ppm)		 SULFER LIMITS*
(ppm)		 VOLTAGE INLET/
OUTLET
AC-1054-115 10x54 7  5 0.5 2 115V 3/4"
AC-1054-230 10x54 7  5 0.5 2 230V 3/4"
AC-1252-115 12x52 7 8 1.0 6 115V 3/4"
AC-1252-230 12x52 7 8 1.0 6 230V 3/4"
AC-1665-115 16x65 15 8 1.2 15 115V 1"
AC-1665-230 16x65 15 8 1.2 15 230V 1"
Filter must be sized correctly to remove iron, manganese or sulfer from the water after the Krudico Air Charger

Filters to use with the Properly Sized Air Charger
Filter Description Model Series Recommended Uses
SFA SERIES
USE WITH AIR CHARGER TO REMOVE
SAND, IRON, MANGANESE, GRIT, OTHER INERTS
S-CFA-1 SERIES
USE WITH AIR CHARGER TO POLISH WATER WITH OVER 2mg/L of SULFER IN NON CHLORINATED WATER
CEN-CFA
SERIES
USE WITH AIR CHARGER TO POLISH WATER WITH UNDER 1 PPM of SULFER IN CHLORINATED WATER AND CHLORAMINES
 
Why buy a Krudico Air Charger?
Iron and Manganese
Iron and Manganese ions have an attraction for oxygen. When oxygen combines with these metals they convert from the dissolved form (Ferrous) to the enlarged precipitated form (Ferric). If the conversion is complete, the ferric and manganese ions can be removed by several filtration methods. In the past several types of filters have been used in an attempt to remove these contaminants with various degrees of success. All of these systems utilize oxygen in one form or another for their conversion from the ferris to the ferric form.
The Air Charger uses a very quiet and oil less air compressor to put large amounts of air (oxygen) into the Air Charger's retention tank.
The Air Chargers air compressor is wired into the pressure switch that controls the well pump. Whenever the well pump is activated, the air compressor also starts up and forces air into the Air Charger tank. This air enters the tank and is forced down to the bottom of the tank through a PVC pipe that has a ten micron porous pipe at the end. The air is forced through this porous pipe and is expelled into the tank in the form of thousands of minute bubbles which start to rise upward through the water.
Incoming raw water enters the top of the tank and is sprayed into a small air pocket that starts to oxidize the iron and manganese ions. This incoming water must now flow downward to the outlet pipe located near the bottom of the tank.
As air bubbles are rising through the water and the new water is flowing downward, a turbulence between the water and the air is created. This turbulence insures that all of the incoming water is completely mixed with oxygen at an accelerated rate, the iron and manganese ions are converted from the ferris form to the ferric within two minutes. Much less time than other methods presently available on the market.
As the iron and manganese ions are now in the enlarged ferric form, they are easily removed by Krudico's SFA filters or by many filters that may already have been installed in the home or business.
   
Hydrogen Sulfide Control
Hydrogen sulfide is a gas created by sulfate reducing bacteria in the well. As the bacteria consume the sulfate ions, a rotten egg odor becomes present in the water. This gas can be removed by adding oxygen to the water which expels the gas and converts the sulfide to basic sulfur. The Air Charger, by adding large amounts of air to the water, is capable of expelling high concentrations of hydrogen sulfide from a water supply without the need of adding chemicals to the water or the need of an atmospheric tank and a repressurization pump. By combining the Air Charger with one of Krudico's S-CFA line of catalytic carbon filters, the basic sulfur is also removed. Water as clean and fresh as a mountal stream is available for showers, bathing, drinking and other household needs.
The "Air Charger" - Water Technology for the twenty first century!!
   


STANDARD FEATURES OF THE KRUDICO AIR CHARGER
   
bullet
115V or 230V Air Compressor
bullet
Air Compressor Mounting Stand
bullet
Electrical Junction Box for Safety
bullet
Superior Fiberglass Mineral Tank
bullet
Non-Corrisive PVC Tank Top
bullet
Interior Non-Corrisive Piping
bullet
Two (2) Check Valves (for preventing accidental backup of water into the air compressor)
bullet
Drain Off Valve (if needed, used to flush out accumulated growths of iron bacteria from the bottom of the tank without removing the air charger from the water line)
bullet
Air Compressor Filter
bullet
Polyethylene Tubing
bullet
Pressure Gauge
bullet
Pressure Regulator
bullet
Air Release Vent (the excessed air is released to prevent air from passing into the household water lines)
bullet
Outside Venting - the air charger includes features that allow released hydrogen gasses to be vented to the outside of the house or business, eliminating the odor to the atmosphere.
bullet
Owners Manual with Complete Easy Installation Instructions
bullet
bullet
Great Service
 
Krudico, Inc. can help you with all your "water treatment needs" if you are needing additional information or not sure what you are looking for above please call customer service at 1-800-211-1369, email us at krudico@iowatelecom.net or fill out the request form and we can help you in finding just what you are looking for.
Krudico Accepted Credit Cards
Krudico Main Window Bottom
Krudico Logo